| Common Name: | COPPER ANTI-SEIZE LUBRICANT 16 OZ., 31163 |
| Manufacturer: | ITW PERMATEX |
| SDS Revision Date: | 11/28/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 768M67 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
PERMATEX(R*)
SAFETY DATA SHEET
REVISION DATE: 28-NOV-2018
VERSION: 7
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER:
PRODUCT NAME: COPPER ANTI-SEIZE LUBRICANT 16 OZ.
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: 31163
RECOMMENDED USE OF THE CHEMICAL AND RESTRICTIONS ON USE:
RECOMMENDED USE: LUBRICANT
USES ADVISED AGAINST: NO INFORMATION AVAILABLE
DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
MANUFACTURER ADDRESS:
ITW PERMATEX
6875 PARKLAND BLVD.
SOLON, OHIO 44139
USA
TELEPHONE:
1-87-PERMATEX
(866) 732-9502
MAY ALSO BE DISTRIBUTED BY:
ITW PERMATEX CANADA
101-2360 BRISTOL CIRCLE
OAKVILLE, ON L6H 6M5
CANADA
TELEPHONE: (800) 924-6994
24-HOUR EMERGENCY PHONE NUMBER:
CHEM-TEL: 800-255-3924
INTERNATIONAL EMERGENCY: 00+1+ 813-248-0585
CONTRACT NUMBER: MIS0003453
E-MAIL ADDRESS: MAIL@PERMATEX.COM
| 2. HAZARDS IDENTIFICATION | |
CLASSIFICATION:
OSHA REGULATORY STATUS:
THIS CHEMICAL IS NOT CONSIDERED HAZARDOUS BY THE 2012 OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200)
LABEL ELEMENTS:
EMERGENCY OVERVIEW:
THE PRODUCT CONTAINS NO SUBSTANCES WHICH AT THEIR GIVEN CONCENTRATION, ARE
CONSIDERED TO BE HAZARDOUS TO HEALTH
APPEARANCE: COPPER
PHYSICAL STATE: PASTE
ODOR: PETROLEUM
PRECAUTIONARY STATEMENTS - STORAGE: STORE IN A WELL-VENTILATED PLACE
PRECAUTIONARY STATEMENTS - DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT
HAZARDS NOT OTHERWISE CLASSIFIED (HNOC): NOT APPLICABLE
OTHER INFORMATION:
- NOTE L:
THE CLASSIFICATION AS A CARCINOGEN 1 DOES NOT APPLY. THE SUBSTANCE CONTAINS
LESS THAN 3% DMSO EXTRACT AS MEASURED BY IP 346. THIS NOTE APPLIES ONLY TO
CERTAIN COMPLEX OIL DERIVED SUBSTANCES IN ANNEX I
UNKNOWN ACUTE TOXICITY:
27.5% OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN TOXICITY
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE(S):
THE PRODUCT CONTAINS NO SUBSTANCES WHICH AT THEIR GIVEN CONCENTRATION, ARE
CONSIDERED TO BE HAZARDOUS TO HEALTH.
| 4. FIRST AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
GENERAL ADVICE: GET MEDICAL ADVICE/ATTENTION IF YOU FEEL UNWELL.
EYE CONTACT:
IF IN EYES: WASH WITH PLENTY OF WATER.
SKIN CONTACT:
IF ON SKIN: WASH WITH SOAP AND WATER.
INHALATION:
IF INHALED. REMOVE TO FRESH AIR.
INGESTION:
IF SWALLOWED: DO NOT INDUCE VOMITING.
SELF-PROTECTION OF THE FIRST AIDER:
ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, TAKE
PRECAUTIONS TO PROTECT THEMSELVES AND PREVENT SPREAD OF CONTAMINATION.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
SYMPTOMS: SEE SECTION 2 FOR MORE INFORMATION.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
NOTE TO PHYSICIANS: TREAT SYMPTOMATICALLY.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA: CARBON DIOXIDE (CO2), DRY CHEMICAL, FOAM
UNSUITABLE EXTINGUISHING MEDIA: NONE
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL: NONE IN PARTICULAR.
EXPLOSION DATA:
SENSITIVITY TO MECHANICAL IMPACT: NONE.
SENSITIVITY TO STATIC DISCHARGE: NONE.
PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
MSHA/NIOSH (APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
PERSONAL PRECAUTIONS:
AVOID CONTACT WITH EYES AND SKIN. WASH THOROUGHLY AFTER HANDLING.
ENVIRONMENTAL PRECAUTIONS:
ENVIRONMENTAL PRECAUTIONS:
SEE SECTION 12 FOR ADDITIONAL ECOLOGICAL INFORMATION.
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
METHODS FOR CONTAINMENT:
PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO.
METHODS FOR CLEANING UP:
ENSURE ADEQUATE VENTILATION. SOAK UP WITH INERT ABSORBENT MATERIAL. SWEEP
UP AND SHOVEL INTO SUITABLE CONTAINERS FOR DISPOSAL.
PREVENTION OF SECONDARY HAZARDS:
CLEAN CONTAMINATED OBJECTS AND AREAS THOROUGHLY OBSERVING ENVIRONMENTAL
REGULATIONS.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
ADVICE ON SAFE HANDLING: AVOID CONTACT WITH SKIN AND EYES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORAGE CONDITIONS: KEEP IN A DRY, COOL AND WELL-VENTILATED PLACE.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS, ACIDS, ALKALIS
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
EXPOSURE GUIDELINES: NIOSH IDLH IMMEDIATELY DANGEROUS TO LIFE OR HEALTH
OTHER INFORMATION:
VACATED LIMITS REVOKED BY THE COURT OF APPEALS DECISION IN AFL-CIO V. OSHA,
965 F.2D 962 (11TH CIR., 1992).
APPROPRIATE ENGINEERING CONTROLS:
ENGINEERING CONTROLS:
SHOWERS
EYEWASH STATIONS
VENTILATION SYSTEMS
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN AND BODY PROTECTION:
WEAR PROTECTIVE NATURAL RUBBER, NITRILE RUBBER, NEOPRENE(TM) OR PVC GLOVES.
RESPIRATORY PROTECTION:
USE NIOSH-APPROVED AIR-PURIFYING RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE OR
CANISTER, AS APPROPRIATE.
GENERAL HYGIENE CONSIDERATIONS:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
REGULAR CLEANING OF EQUIPMENT, WORK AREA AND CLOTHING IS RECOMMENDED.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
9.1. INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
PHYSICAL STATE: PASTE
APPEARANCE: COPPER
ODOR: PETROLEUM
ODOR THRESHOLD: NO INFORMATION AVAILABLE
PROPERTY VALUES REMARKS - METHOD
PH NO INFORMATION AVAILABLE
MELTING POINT / FREEZING POINT NO INFORMATION AVAILABLE
BOILING POINT / BOILING RANGE NO INFORMATION AVAILABLE
FLASH POINT 216 DEG. C / 421 DEG. F
EVAPORATION RATE NO INFORMATION AVAILABLE BUTYL ACETATE = 1
FLAMMABILITY (SOLID, GAS) NO INFORMATION AVAILABLE
FLAMMABILITY LIMIT IN AIR:
UPPER FLAMMABILITY LIMIT NO INFORMATION AVAILABLE
LOWER FLAMMABILITY LIMIT NO INFORMATION AVAILABLE
VAPOR PRESSURE NO INFORMATION AVAILABLE
VAPOR DENSITY NO INFORMATION AVAILABLE AIR = 1
RELATIVE DENSITY 1.21
WATER SOLUBILITY INSOLUBLE IN WATER
SOLUBILITY(IES) NO INFORMATION AVAILABLE
PARTITION COEFFICIENT NO INFORMATION AVAILABLE
AUTOIGNITION TEMPERATURE NO INFORMATION AVAILABLE
DECOMPOSITION TEMPERATURE NO INFORMATION AVAILABLE
KINEMATIC VISCOSITY NO INFORMATION AVAILABLE
DYNAMIC VISCOSITY NO INFORMATION AVAILABLE
EXPLOSIVE PROPERTIES NO INFORMATION AVAILABLE
OXIDIZING PROPERTIES NO INFORMATION AVAILABLE
OTHER INFORMATION:
SOFTENING POINT NO INFORMATION AVAILABLE
MOLECULAR WEIGHT NO INFORMATION AVAILABLE
VOC CONTENT (%) 0
DENSITY NO INFORMATION AVAILABLE
BULK DENSITY NO INFORMATION AVAILABLE
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: NO INFORMATION AVAILABLE
CHEMICAL STABILITY: STABLE UNDER NORMAL CONDITIONS
POSSIBILITY OF HAZARDOUS REACTIONS: NONE UNDER NORMAL PROCESSING.
CONDITIONS TO AVOID: EXCESSIVE HEAT.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS, ACIDS, ALKALIS
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON OXIDES
METAL OXIDES
HALOGENATED COMPOUNDS
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION: MAY CAUSE IRRITATION OF RESPIRATORY TRACT.
EYE CONTACT:
CONTACT WITH EYES MAY CAUSE IRRITATION. MAY CAUSE REDNESS AND TEARING OF
THE EYES.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION AND/OR DERMATITIS.
INGESTION: INGESTION MAY CAUSE IRRITATION TO MUCOUS MEMBRANES.
INFORMATION ON TOXICOLOGICAL EFFECTS:
SYMPTOMS: NO INFORMATION AVAILABLE.
DELAYED AND IMMEDIATE EFFECTS AS WELL AS CHRONIC EFFECTS FROM SHORT AND
LONG-TERM EXPOSURE:
SENSITIZATION: NO INFORMATION AVAILABLE.
GERM CELL MUTAGENICITY: NO INFORMATION AVAILABLE.
CARCINOGENICITY:
THE TABLE BELOW INDICATES WHETHER EACH AGENCY HAS LISTED ANY INGREDIENT AS
A CARCINOGEN.
ACGIH (AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS):
A2 - SUSPECTED HUMAN CARCINOGEN
IARC (INTERNATIONAL AGENCY FOR RESEARCH ON CANCER):
GROUP 1 - CARCINOGENIC TO HUMANS
NOT CLASSIFIABLE AS A HUMAN CARCINOGEN
NTP (NATIONAL TOXICOLOGY PROGRAM): KNOWN - KNOWN CARCINOGEN
OSHA (OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION OF THE US DEPARTMENT OF
LABOR): X - PRESENT
CHRONIC TOXICITY: MAY CAUSE ADVERSE LIVER EFFECTS.
TARGET ORGAN EFFECTS:
CENTRAL VASCULAR SYSTEM (CVS), EYES, KIDNEY, LIVER, RESPIRATORY SYSTEM,
SKIN.
THE FOLLOWING VALUES ARE CALCULATED BASED ON CHAPTER 3.1 OF THE GHS
DOCUMENT.:
ATEMIX (ORAL): 16277 MG/KG
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
9.5% OF THE MIXTURE CONSISTS OF COMPONENT(S) OF UNKNOWN HAZARDS TO THE
AQUATIC ENVIRONMENT
PERSISTENCE AND DEGRADABILITY: NO INFORMATION AVAILABLE.
BIOACCUMULATION: NO INFORMATION AVAILABLE.
MOBILITY: NO INFORMATION AVAILABLE.
OTHER ADVERSE EFFECTS: NO INFORMATION AVAILABLE
| 13. DISPOSAL CONSIDERATIONS | |
WASTE TREATMENT METHODS:
DISPOSAL OF WASTES:
DISPOSAL SHOULD BE IN ACCORDANCE WITH APPLICABLE REGIONAL, NATIONAL AND
LOCAL LAWS AND REGULATIONS.
CONTAMINATED PACKAGING: DO NOT REUSE CONTAINER.
US EPA WASTE NUMBER: NOT APPLICABLE
| 14. TRANSPORT INFORMATION | |
DOT:
PROPER SHIPPING NAME: NOT REGULATED
IATA:
PROPER SHIPPING NAME: NOT REGULATED
IMDG:
PROPER SHIPPING NAME: NOT REGULATED
| 15. REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES:
TSCA: COMPLIES
DSL/NDSL: COMPLIES
EINECS/ELINCS: COMPLIES
ENCS: NOT DETERMINED
IECSC: COMPLIES
KECL: COMPLIES
PICCS: COMPLIES
AICS: COMPLIES
LEGEND:
TSCA: UNITED STATES TOXIC SUBSTANCES CONTROL ACT SECTION 8(B) INVENTORY
DSL/NDSL: CANADIAN DOMESTIC SUBSTANCES LIST/NON-DOMESTIC SUBSTANCES LIST
EINECS/ELINCS:
EUROPEAN INVENTORY OF EXISTING CHEMICAL SUBSTANCES/EUROPEAN LIST OF
NOTIFIED CHEMICAL SUBSTANCES
ENCS: JAPAN EXISTING AND NEW CHEMICAL SUBSTANCES
IECSC: CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES
KECL: KOREAN EXISTING AND EVALUATED CHEMICAL SUBSTANCES
PICCS: PHILIPPINES INVENTORY OF CHEMICALS AND CHEMICAL SUBSTANCES
AICS: AUSTRALIAN INVENTORY OF CHEMICAL SUBSTANCES
US FEDERAL REGULATIONS:
SARA 313:
SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION
ACT OF 1986 (SARA). THIS PRODUCT CONTAINS A CHEMICAL OR CHEMICALS WHICH ARE
SUBJECT TO THE REPORTING REQUIREMENTS OF THE ACT AND TITLE 40 OF THE CODE
OF FEDERAL REGULATIONS, PART 372
CHEMICAL NAME SARA 313 - THRESHOLD VALUES %
COPPER - 7440-50-8 1.0
SARA 311/312 HAZARD CATEGORIES:
ACUTE HEALTH HAZARD: YES
CHRONIC HEALTH HAZARD: NO
FIRE HAZARD: NO
REACTIVE HAZARD: NO
SUDDEN RELEASE OF PRESSURE HAZARD: NO
CWA (CLEAN WATER ACT):
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES WHICH ARE REGULATED
POLLUTANTS PURSUANT TO THE CLEAN WATER ACT (40 CFR 122.21 AND 40 CFR
122.42)
CERCLA:
THIS MATERIAL, AS SUPPLIED, CONTAINS ONE OR MORE SUBSTANCES REGULATED AS A
HAZARDOUS SUBSTANCE UNDER THE COMPREHENSIVE ENVIRONMENTAL RESPONSE
COMPENSATION AND LIABILITY ACT (CERCLA) (40 CFR 302)
US STATE REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT IS NOT KNOWN TO CONTAIN ANY CHEMICALS LISTED AS CARCINOGENS OR
REPRODUCTIVE TOXINS.
U.S. STATE RIGHT-TO-KNOW REGULATIONS:
CHEMICAL NAME NEW JERSEY MASSACHUSETTS PENNSYLVANIA
LIMESTONE X X X
1317-65-3
MAGNESIUM SILICATE X X X
14807-96-6
COPPER X X X
7440-50-8
GRAPHITE X X X
7782-42-5
U.S. EPA LABEL INFORMATION:
EPA PESTICIDE REGISTRATION NUMBER: NOT APPLICABLE
WHMIS HAZARD CLASS: NON-CONTROLLED
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION OF | |
THE LAST REVISION
NFPA:
HEALTH HAZARDS 1
FLAMMABILITY 1
INSTABILITY 0
HMIS:
HEALTH HAZARDS 1
FLAMMABILITY 1
PHYSICAL HAZARDS 0
PERSONAL PROTECTION B
NFPA (NATIONAL FIRE PROTECTION ASSOCIATION)
HMIS (HAZARDOUS MATERIAL INFORMATION SYSTEM)
REVISION DATE: 28-NOV-2018
DISCLAIMER:
THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT TO THE BEST
OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION.
THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING,
USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT
TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION
RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR
SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY
PROCESS, UNLESS SPECIFIED IN THE TEXT.