| Common Name: | COMM 5GL WB ACRYLIC PRIMER GRAY, 292603 |
| Manufacturer: | RUST-OLEUM |
| SDS Revision Date: | 4/15/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 39UL72 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DATE PRINTED: 4/15/2015
SAFETY DATA SHEET
RUST-OLEUM CORPORATION
TRUSTED QUALITY SINCE 1921
WWW.RUSTOLEUM.COM
| 1. IDENTIFICATION |  |
PRODUCT NAME: COMM 5GL WB ACRYLIC PRIMER GRAY
PRODUCT IDENTIFIER: 292603
PRODUCT USE/CLASS: PRIMER/WATERBASED ACRYLIC
REVISION DATE: 4/15/2015
SUPERCEDES DATE: NEW SDS
SUPPLIER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
MANUFACTURER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
EMERGENCY TELEPHONE:
24 HOUR HOTLINE: 847-367-7700
PREPARER: REGULATORY DEPARTMENT
| 2. HAZARD IDENTIFICATION | |
EMERGENCY OVERVIEW:
MAY CAUSE EYE, SKIN, OR RESPIRATORY TRACT IRRITATION. KEEP OUT OF REACH OF
CHILDREN. HARMFUL IF INHALED. CAUSES EYE IRRITATION. USE VENTILATION
NECESSARY TO KEEP EXPOSURES BELOW RECOMMENDED EXPOSURE LIMITS, IF ANY.
CLASSIFICATION:
SYMBOL(S) OF PRODUCT: HEALTH HAZARD
SIGNAL WORD: WARNING
GHS HAZARD STATEMENTS:
ACUTE TOXICITY, DERMAL, CATEGORY 5:
H313: MAY BE HARMFUL IN CONTACT WITH SKIN.
SKIN IRRITATION, CATEGORY 2:
H315: CAUSES SKIN IRRITATION.
ASPIRATION HAZARD, CATEGORY 2:
H305: MAY BE HARMFUL IF SWALLOWED AND ENTERS AIRWAYS.
SKIN IRRITATION, CATEGORY 3:
H316: CAUSES MILD SKIN IRRITATION.
EYE IRRITATION, CATEGORY 2B:
H320: CAUSES EYE IRRITATION.
GHS PRECAUTIONARY STATEMENTS:
P102: KEEP OUT OF REACH OF CHILDREN.
P103: READ LABEL BEFORE USE.
P202:
DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
P234: KEEP ONLY IN ORIGINAL CONTAINER.
P260: DO NOT BREATHE DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
P262: DO NOT GET IN EYES, ON SKIN, OR ON CLOTHING.
P264: WASH ... THOROUGHLY AFTER HANDLING.
P270: DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P273: AVOID RELEASE TO THE ENVIRONMENT.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P281: USE PERSONAL PROTECTIVE EQUIPMENT AS REQUIRED.
P285: IN CASE OF INADEQUATE VENTILATION WEAR RESPIRATORY PROTECTION.
P312: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
P335: BRUSH OFF LOOSE PARTICLES FROM SKIN.
P351: RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES.
P374: FIGHT FIRE WITH NORMAL PRECAUTIONS FROM A REASONABLE DISTANCE.
P402: STORE IN A DRY PLACE.
P321: SPECIFIC TREATMENT (SEE ... ON THIS LABEL).
P352: WASH WITH PLENTY OF SOAP AND WATER.
P362: TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
P332+P313:
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
P403+P233:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
P302+P350:
IF ON SKIN: GENTLY WASH WITH PLENTY OF SOAP AND WATER.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
HAZARDOUS SUBSTANCES:
CHEMICAL NAME CAS-NO. WT.% GHS GHS
RANGE SYMBOLS STATEMENTS
LIMESTONE 1317-65-3 10-25
TITANIUM DIOXIDE 13463-67-7 2.5-10
ETHYLENE GLYCOL 107-21-1 1.0-2.5
HYDROUS MAGNESIUM SILICATE 14807-96-6 1.0-2.5
ZINC OXIDE 1314-13-2 1.0-2.5
MLEND OF NONIONIC SURFACTANTS PROPRIETARY 0.1-1.0
THE TEXT FOR GHS HAZARD STATEMENTS SHOWN ABOVE (IF ANY) IS GIVEN IN THE
"16. OTHER INFORMATION" SECTION.
| 4. FIRST-AID MEASURES | |
FIRST AID - EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES
HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION. DO NOT ALLOW RUBBING OF EYES
OR KEEPING EYES CLOSED.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.
FIRST AID - INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL ATTENTION. DO
NOT USE MOUTH-TO-MOUTH RESUSCITATION. IF YOU EXPERIENCE DIFFICULTY IN
BREATHING, LEAVE THE AREA TO OBTAIN FRESH AIR. IF CONTINUED DIFFICULTY IS
EXPERIENCED, GET MEDICAL ASSISTANCE IMMEDIATELY.
FIRST AID - INGESTION:
SWALLOWING LESS THAN AN OUNCE WILL NOT CAUSE SIGNIFICANT HARM. FOR LARGER
AMOUNTS, DO NOT INDUCE VOMITING, BUT GIVE ONE OR TWO GLASSES OF WATER TO
DRINK AND GET MEDICAL ATTENTION. IF SWALLOWED, RINSE MOUTH WITH WATER. IF
FEELING UNWELL, GET MEDICAL ATTENTION.
| 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
ALCOHOL FILM FORMING FOAM, CARBON DIOXIDE, DRY CHEMICAL, DRY SAND, WATER
FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS:
NO UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED. KEEP CONTAINERS TIGHTLY
CLOSED. FLASH POINT IS TESTED TO BE GREATER THAN 200 DEGREES F.
SPECIAL FIREFIGHTING PROCEDURES:
WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT BUILDUP OF STEAM.
IF WATER IS USED, FOG NOZZLES ARE PREFERRED.
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
IF SPILLED, CONTAIN SPILLED MATERIAL AND REMOVE WITH INERT ABSORBENT.
DISPOSE OF CONTAMINATED ABSORBENT, CONTAINER, AND UNUSED CONTENTS IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. DO NOT INCINERATE
CLOSED CONTAINERS
| 7. HANDLING AND STORAGE | |
HANDLING:
WASH THOROUGHLY AFTER HANDLING. WASH HANDS BEFORE EATING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. USE ONLY WITH ADEQUATE
VENTILATION. FOLLOW ALL MSDS/LABEL PRECAUTIONS EVEN AFTER CONTAINER IS
EMPTIED BECAUSE IT MAY RETAIN PRODUCT RESIDUES. AVOID BREATHING FUMES,
VAPORS, OR MIST. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
STORAGE:
STORE IN A DRY, WELL VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN
NOT IN USE.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CHEMICAL NAME CAS-NO. WEIGHT % LESS THAN
LIMESTONE 1317-65-3 20.0
TITANIUM DIOXIDE 13463-67-7 10.0
ETHYLENE GLYCOL 107-21-1 5.0
HYDROUS MAGNESIUM SILICATE 14807-96-6 5.0
ZINC OXIDE 1314-13-2 5.0
MLEND OF NONIONIC SURFACTANTS PROPRIETARY 1.0
CHEMICAL NAME ACGIH ACGIH OSHA OSHA
TLV-TWA TLV-STEL PEL-TWA PEL-CEILING
LIMESTONE 15 MG/M3 N.E. 5 MG/M3 N.E.
(TOTAL DUST, (RESPIRABLE
OSHA) DUST)
TITANIUM DIOXIDE 10 MG/M3 N.E. 15 MG/M3 N.E.
(TOTAL DUST) [TOTAL DUST]
ETHYLENE GLYCOL N.E. 39 PPM N.E. N.E.
HYDROUS MAGNESIUM 2 MG/M3 N.E. 20 MPPCF N.E.
SILICATE (RESPIRABLE (MINERAL
DUST) DUST
<1% QUARTZ)
ZINC OXIDE 2 MG/M3 10 MG/M3 5 MG/M3 N.E.
(RESPIRABLE (RESPIRABLE (RESPIRABLE
DUST) DUST) DUST OR
FUME)
MLEND OF NONIONIC
SURFACTANTS
PERSONAL PROTECTION:
ENGINEERING CONTROLS:
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
PREVENT BUILD-UP OF VAPORS BY OPENING ALL DOORS AND WINDOWS TO ACHIEVE
CROSS-VENTILATION.
RESPIRATORY PROTECTION:
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA 1910.134 AND ANSI Z88.2
REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS WARRANT A
RESPIRATOR'S USE.
SKIN PROTECTION:
USE GLOVES TO PREVENT PROLONGED SKIN CONTACT. NITRILE OR NEOPRENE GLOVES
MAY AFFORD ADEQUATE SKIN PROTECTION.
EYE PROTECTION:
USE SAFETY EYEWEAR DESIGNED TO PROTECT AGAINST SPLASH OF LIQUIDS.
OTHER PROTECTIVE EQUIPMENT:
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER GUIDANCE
REGARDING TYPES OF PERSONAL PROTECTIVE EQUIPMENT AND THEIR APPLICATIONS.
HYGIENIC PRACTICES:
WASH THOROUGHLY WITH SOAP AND WATER BEFORE EATING, DRINKING OR SMOKING.
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND LAUNDER BEFORE REUSE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID
PHYSICAL STATE: LIQUID
ODOR: MILD
ODOR THRESHOLD: N.E.
RELATIVE DENSITY: 1.288
PH: 9.2
FREEZE POINT, DEG. C: N.D.
VISCOSITY: NO INFORMATION
SOLUBILITY IN WATER: MISCIBLE
PARTITION COEFFICIENT, N-OCTANOL/WATER: NO INFORMATION
DECOMPOSTION TEMP., DEG. C: NO INFORMATION
BOILING RANGE, DEG. C: 0 - 999
EXPLOSIVE LIMITS, VOL%: 0.9 - 17.7
FLAMMABILITY: DOES NOT SUPPORT COMBUSTION
FLASH POINT, DEG. C: >93
EVAPORATION RATE: SLOWER THAN ETHER
AUTO-IGNITION TEMP., DEG. C: NO INFORMATION
VAPOR DENSITY: HEAVIER THAN AIR
VAPOR PRESSURE: N.D.
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
| 10. STABILITY AND REACTIVITY | |
CONDITIONS TO AVOID: AVOID CONTACT WITH STRONG ACID AND STRONG BASES.
INCOMPATIBILITY:
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG
ALKALIES.
HAZARDOUS DECOMPOSITION:
WHEN HEATED TO DECOMPOSITION, IT EMITS ACRID SMOKE AND IRRITATING FUMES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
STABILITY: THIS PRODUCT IS STABLE UNDER NORMAL STORAGE CONDITIONS.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECTS OF OVEREXPOSURE - EYE CONTACT:
IRRITATING, AND MAY INJURE EYE TISSUE IF NOT REMOVED PROMPTLY.
EFFECTS OF OVEREXPOSURE - SKIN CONTACT:
LOW HAZARD FOR USUAL INDUSTRIAL HANDLING OR COMMERCIAL HANDLING BY TRAINED
PERSONNEL.
EFFECTS OF OVEREXPOSURE - INHALATION:
HIGH GAS, VAPOR, MIST OR DUST CONCENTRATIONS MAY BE HARMFUL IF INHALED.
AVOID BREATHING FUMES, SPRAY, VAPORS, OR MIST.
EFFECTS OF OVEREXPOSURE - INGESTION:
SUBSTANCE MAY BE HARMFUL IF SWALLOWED.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS:
CONTAINS TITANIUM DIOXIDE. TITANIUM DIOXIDE IS LISTED AS A GROUP 2B-
"POSSIBLY CARCINOGENIC TO HUMANS" BY IARC. NO SIGNIFICANT EXPOSURE TO
TITANIUM DIOXIDE IS THOUGHT TO OCCUR DURING THE USE OF PRODUCTS IN WHICH
TITANIUM DIOXIDE IS BOUND TO OTHER MATERIALS, SUCH AS IN PAINTS DURING
BRUSH APPLICATION OR DRYING. RISK OF OVEREXPOSURE DEPENDS ON DURATION AND
LEVEL OF EXPOSURE TO DUST FROM REPEATED SANDING OF SURFACES OR SPRAY MIST
AND THE ACTUAL CONCENTRATION OF TITANIUM DIOXIDE IN THE FORMULA. (REF:
IARC MONOGRAPH, VOL. 93, 2010)
PRIMARY ROUTE(S) OF ENTRY:
EYE CONTACT, INGESTION, INHALATION, SKIN ABSORPTION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW:
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
13463-67-7 TITANIUM DIOXIDE >10000 MG/KG RAT N.I. N.I.
107-21-1 ETHYLENE GLYCOL 4000 MG/KG RAT N.I. N.I.
1314-13-2 ZINC OXIDE >5000 MG/KG RAT N.I. N.I.
N.I.: NO INFORMATION
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: PRODUCT IS A MIXTURE OF LISTED COMPONENTS.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
DISPOSE OF MATERIAL IN ACCORDANCE TO LOCAL, STATE, AND FEDERAL REGULATIONS
AND ORDINANCES. DO NOT ALLOW TO ENTER WATERWAYS, WASTEWATER, SOIL, STORM
DRAINS OR SEWER SYSTEMS.
| 14. TRANSPORT INFORMATION | |
DOMESTIC INTERNATIONAL AIR TDG
(USDOT) (IMDG) (IATA) (CANADA)
UN NUMBER N.A. N.A. N.A. N.A.
PROPER SHIPPING NAME NOT NOT NOT NOT
REGULATED REGULATED REGULATED REGULATED
HAZARD CLASS N.A. N.A. N.A. N.A.
PACKING GROUP N.A. N.A. N.A. N.A.
LIMITED QUANTITY NO NO NO NO
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
ETHYLENE GLYCOL 107-21-1
ZINC OXIDE 1314-13-2
TOXIC SUBSTANCES CONTROL ACT:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
CHEMICAL NAME CAS-NO.
SODIUM NITRITE 7632-00-0
5-CHLORO-2-METHYL-4-ISOTHIAZOLIN-3-ONE 26172-55-4
METHYL-4-ISOTHIAZOLIN-3-ONE 2682-20-4
CALIFORNIA PROPOSITION 65:
CHEMICAL NAME CAS-NO.
TITANIUM DIOXIDE 13463-67-7
MLEND OF NONIONIC SURFACTANTS PROPRIETARY
CALIFORNIA PROPOSITION 65 REPRODUCTIVE TOXINS:
CHEMICAL NAME CAS-NO.
MLEND OF NONIONIC SURFACTANTS PROPRIETARY
INTERNATIONAL REGULATIONS:
CANADIAN WHMIS:
THIS SDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED PRODUCT
REGULATIONS EXCEPT FOR THE USE OF THE 16 HEADINGS.
| 16. OTHER INFORMATION | |
HMIS RATINGS:
HEALTH 2*
FLAMMABILITY 1
PHYSICAL HAZARD 0
PERSONAL PROTECTION X
CANADIAN WHMIS CLASS: D2A
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 1
INSTABILITY 0
VOLATILE ORGANIC COMPOUNDS, G/L: 84
MSDS REVISION DATE: 4/15/2015
REASON FOR REVISION: NO INFORMATION
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
ICONS FOR GHS PICTOGRAMS SHOWN IN SECTION 3 DESCRIBING EACH INGREDIENT:
NO GHS PICTOGRAMS EXIST FOR SECTION 3
RUST-OLEUM CORPORATION BELIEVES, TO THE BEST OF ITS KNOWLEDGE, INFORMATION
AND BELIEF, THE INFORMATION CONTAINED HEREIN TO BE ACCURATE AND RELIABLE
AS OF THE DATE OF THIS SAFETY DATA SHEET. HOWEVER, BECAUSE THE CONDITIONS
OF HANDLING, USE, AND STORAGE OF THESE MATERIALS ARE BEYOND OUR CONTROL,
WE ASSUME NO RESPONSIBILITY OR LIABILITY FOR PERSONAL INJURY OR PROPERTY
DAMAGE INCURRED BY THE USE OF THESE MATERIALS. RUST-OLEUM CORPORATION
MAKES NO WARRANTY, EXPRESSED OR IMPLIED, REGARDING THE ACCURACY OR
RELIABILITY OF THE DATA OR RESULTS OBTAINED FROM THEIR USE. ALL MATERIALS
MAY PRESENT UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION. THE
INFORMATION AND RECOMMENDATIONS IN THIS MATERIAL SAFETY DATA SHEET ARE
OFFERED FOR THE USERS' CONSIDERATION AND EXAMINATION. IT IS THE
RESPONSIBILITY OF THE USER TO DETERMINE THE FINAL SUITABILITY OF THIS
INFORMATION AND TO COMPLY WITH ALL APPLICABLE INTERNATIONAL, FEDERAL,
STATE, AND LOCAL LAWS AND REGULATIONS.