| Common Name: | LITHIUM-ION BATTERY PACKS (GREATER THAN 100 WATT HOURS) |
| Manufacturer: | STANLEY BLACK & DECKER |
| SDS Revision Date: | 6/2/2021 |
| SDS Format: | No Format Specified |
| Item Number(s): | 339YG0, 339YG2, 56DK65, 56DK67, 56DK68, 56DK70, 61UU92, 783WJ5, 783WJ6, 783WJ7, 783WJ8, 786VL8, 796P68, 796P71, 801A79, 810XA8, 814KJ8, 814KJ9, 814KK0, 814KK1, 814LP4, 814LR0, 814LR1, 814LR5 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
PRODUCT SAFETY DATA SHEET - NORTH AMERICA
PRODUCT NAME: LITHIUM-ION BATTERY PACKS (GREATER THAN 100 WATT HOURS)
| SECTION 1 - IDENTIFICATION |  |
PRODUCT IDENTIFIER: DETACHABLE BATTERY PACKS
BLACK & DECKER:
(20 VOLT MAX/60 VOLT MAX) - LBXR2560 (150 WHR), LBX2560 (150 WHR)
DEWALT:
(20 VOLT MAX) - DCB206 (120 WHR), DCB208 (160 WHR), DCB210 (200WHR)
(40 VOLT MAX) - DCB404 (160WHR), DCB406 (240WHR), DCB407 (300WHR)
(20 VOLT MAX/60 VOLT MAX):
DCB606 (120 WHR):
SHIPPED WITHIN TOOL OR BATTERY ALONE WITHOUT TRANSPORT CAP
DCB609 (180 WHR):
SHIPPED WITHIN TOOL OR BATTERY ALONE WITHOUT TRANSPORT CAP
DCB609G (180 WHR):
SHIPPED WITHIN TOOL OR BATTERY ALONE WITHOUT TRANSPORT CAP
DCB612 (240 WHR):
SHIPPED WITHIN TOOL OR BATTERY ALONE WITHOUT TRANSPORT CAP
DCB615 (300 WHR):
SHIPPED WITHIN TOOL OR BATTERY ALONE WITHOUT TRANSPORT CAP
CRAFTSMAN:
(20 VOLT MAX): CMCB206 (120 WHR), CMCB209 (180 WHR)
(60 VOLT MAX):
CMCB6025 (150 WHR) - SHIPPED WITHIN TOOL
CMCB6050 (300 WHR) - SHIPPED WITHIN TOOL
CMCB6075:
(150 WHR) - SHIPPED WITH TOOL OR BATTERY ALONE
(450 WHR) - SHIPPED WITHIN TOOL
CUB CADET:
(60 VOLT MAX):
CC6025 (150 WHR) - SHIPPED WITHIN TOOL
CC6050 (300 WHR) - SHIPPED WITHIN TOOL
NOTES:
1. A SUFFIX FOLLOWING CATALOG NUMBER (I.E., "-XJ") MAY BE USED TO DESIGNATE
END MARKET.
2. BATTERIES MAY BE SHIPPED IN KITS WITH THE PRODUCTS THEY ARE INTENDED TO
POWER.
MANUFACTURER NAME: STANLEY BLACK & DECKER
MANUFACTURER ADDRESS:
1000 STANLEY DRIVE
NEW BRITAIN, CT 06053
PHONE NUMBER: 1-860-225-5111
EMERGENCY PHONE NUMBER:
CHEMTREC: +1 703-741-5970 / +1 800-424-9300
RECOMMENDED USE: TO POWER STANLEY BLACK & DECKER PRODUCTS
USES ADVISED AGAINST: SEE INSTRUCTION MANUAL PROVIDED WITH PRODUCT.
| SECTION 2 - HAZARDS IDENTIFICATION | |
CLASSIFICATION:
THESE BATTERIES ARE NOT CONSIDERED HAZARDOUS BY THE 2012 OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200). THE BATTERIES REFERENCED IN
THIS DOCUMENT ARE CONSIDERED "ARTICLES," NOT "MATERIALS," AS DEFINED BY
THE OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION'S HAZARD COMMUNICATION
STANDARD, AND AS SUCH ARE EXEMPTED FROM THE REQUIREMENTS TO PUBLISH MSDS
SHEETS PER THE CODE OF FEDERAL REGULATIONS 29 CFR 1910.1200 (B)(6)(V).
THE HAZARDS INDICATED BELOW COVER THE ABNORMAL SITUATION WHERE A BATTERY
RUPTURES.
ACUTE TOXICITY - ORAL: CATEGORY 4
ACUTE TOXICITY - DERMAL: CATEGORY 4
ACUTE TOXICITY - INHALATION (VAPORS): CATEGORY 3
ACUTE TOXICITY - INHALATION (DUSTS/MISTS): CATEGORY 2
SKIN CORROSION/IRRITATION: CATEGORY 1 SUB-CATEGORY B
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 1
SKIN SENSITIZATION: CATEGORY 1
CARCINOGENICITY: CATEGORY 1A
REPRODUCTIVE TOXICITY: CATEGORY 1A
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE): CATEGORY 3
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): CATEGORY 1
GHS LABEL ELEMENTS, INCLUDING PRECAUTIONARY STATEMENTS:
EMERGENCY OVERVIEW:
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
HARMFUL IF SWALLOWED
HARMFUL IN CONTACT WITH SKIN
FATAL IF INHALED
CAUSES SEVERE SKIN BURNS AND EYE DAMAGE
MAY CAUSE AN ALLERGIC SKIN REACTION
MAY CAUSE CANCER
MAY DAMAGE FERTILITY OR THE UNBORN CHILD
MAY CAUSE RESPIRATORY IRRITATION
CAUSES DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE
SKULLS AND CROSSBONES
HEALTH HAZARD
CORROSION
EXCLAMATION MARK
THIS PRODUCT IS AN ARTICLE (BATTERY) WHICH CONTAINS CHEMICAL SUBSTANCES.
INTENDED USE OF THE PRODUCT SHOULD NOT RESULT IN EXPOSURE TO THE CHEMICAL
SUBSTANCES. IN CASE OF RUPTURE, THE ABOVE HAZARDS EXIST.
APPEARANCE: SOLID
PHYSICAL STATE: SOLID
ODOR: NONE
| SECTION 3 - COMPOSITION / INFORMATION ON INGREDIENTS | |
THIS BATTERY IS AN ARTICLE AS DEFINED BY 29 CFR 1910.1200. EXPOSURE TO
HAZARDOUS INGREDIENTS IS NOT ANTICIPATED UNDER NORMAL PRODUCT USE.
CHEMICAL NAME CAS NO. WEIGHT - % TRADE SECRET
COPPER 7440-50-8 10-30 *
STEEL MANUFACTURE, CHEMICALS 65997-19-5 7-13 *
LITHIUM HEXAFLUOROPHOSPHATE 21324-40-3 1-3 *
(LiPF6)
ALUMINUM 7429-90-5 7-13 *
LITHIUM MANGANESE OXIDE 12057-17-9 5-10 *
(LiMn2O4)
LITHIUM COBALT OXIDE 12190-79-3 5-10 *
(LiCoO2)
LITHIUM NICKEL MANGANESE 346417-97-8 5-10 *
COBALT OXIDE (LiNiMnCoO2)
LITHIUM NICKEL COBALT ALUMINUM 193214-24-3 5-10 *
OXIDE (LiNiCoAlO2)
NICKEL 7440-02-0 3-7 *
MIXED ORGANIC CARBONATES 10-14 *
* THE EXACT PERCENTAGE (CONCENTRATION) OF COMPOSITION HAS BEEN WITHHELD
AS A TRADE SECRET. COMPOSITION OF ORGANIC CARBONATES IN THE ELECTROLYTE
SOLVENT VARIES.
| SECTION 4 - FIRST-AID MEASURES | |
FIRST AID:
EYES:
FLUSH EYES WITH LUKEWARM WATER FOR AT LEAST 30 MINUTES WHILE HOLDING THE
EYELIDS OPEN. SEEK IMMEDIATE MEDICAL CARE.
FIRST AID:
SKIN:
REMOVE CONTAMINATED CLOTHING, SHOES AND LEATHER GOODS. FLUSH WITH WATER
FOR AT LEAST 30 MINUTES. SEEK MEDICAL ATTENTION IF SYMPTOMS PERSIST.
FIRST AID:
INGESTION:
NEVER GIVE ANYTHING BY MOUTH IF VICTIM IS UNCONSCIOUS. RINSE MOUTH
THOROUGHLY WATER. DO NOT INDUCE VOMITING. SEEK IMMEDIATE MEDICAL ATTENTION.
FIRST AID:
INHALATION: REMOVE PERSON TO FRESH AIR AWAY FROM SOURCE OF CONTAMINATION.
| SECTION 5 - FIRE-FIGHTING MEASURES | |
GENERAL FIRE HAZARDS:
SEE SECTION 9 FOR FLAMMABILITY PROPERTIES.
BATTERY CELLS MAY RUPTURE WHEN EXPOSED TO EXCESSIVE HEAT. ELECTROLYTE
SOLUTION IS FLAMMABLE.
HAZARDOUS COMBUSTION PRODUCTS:
MAY RELEASE TOXIC FUMES IF BURNED OR EXPOSED TO FIRE.
EXTINGUISHING MEDIA:
USE APPROPRIATE EXTINGUISHING AGENT FOR SURROUNDING FIRE. FOR DAMAGED OR
RUPTURED CELLS, USE CLASS D EXTINGUISHER OR OTHER APPROPRIATE AGENT.
CLASS C FIRE EXTINGUISHERS SHOULD BE USED TO EXTINGUISH ELECTRICAL FIRES.
DO NOT USE WATER TO EXTINGUISH ELECTRICAL OR RUPTURED CELL RELATED FIRES.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
FIREFIGHTERS SHOULD WEAR FULL PROTECTIVE GEAR.
NFPA RATINGS:
HEALTH 0
FIRE 0
REACTIVITY 0
HAZARD SCALE:
0 = MINIMAL
1 = SLIGHT
2 = MODERATE
3 = SERIOUS
4 = SEVERE
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
CONTAINMENT PROCEDURES:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK.
CLEAN-UP PROCEDURES:
ABSORB SPILL WITH INERT MATERIAL. SHOVEL MATERIAL INTO APPROPRIATE
CONTAINER FOR DISPOSAL. CLEAN SPILL AREA WITH DETERGENT AND WATER;
COLLECT WASH WATER FOR PROPER DISPOSAL.
EVACUATION PROCEDURES: ISOLATE AREA. KEEP UNNECESSARY PERSONNEL AWAY.
SPECIAL PROCEDURES: AVOID SKIN CONTACT WITH THE SPILLED MATERIAL.
| SECTION 7 - HANDLING AND STORAGE | |
HANDLING PROCEDURES: AVOID DAMAGING OR RUPTURING BATTERY.
STORAGE PROCEDURES:
STORE IN A DRY LOCATION AT ROOM TEMPERATURE. AVOID EXTREME HEAT OR FIRE.
KEEP OUT OF REACH OF CHILDREN.
| SECTION 8 - EXPOSURE CONTROLS / PERSONAL PROTECTION | |
A:
COMPONENT EXPOSURE LIMITS:
ACGIH, OSHA, AND NIOSH HAVE NOT DEVELOPED EXPOSURE LIMITS FOR ANY OF THIS
PRODUCT'S COMPONENTS.
ENGINEERING CONTROLS: NOT NECESSARY UNDER NORMAL PRODUCT USE CONDITIONS.
PERSONAL PROTECTIVE EQUIPMENT:
PERSONAL PROTECTIVE EQUIPMENT:
EYES/FACE:
NOT NECESSARY UNDER NORMAL PRODUCT USE CONDITIONS. WEAR SAFETY GLASSES
IF HANDLING A DAMAGED BATTERY.
PERSONAL PROTECTIVE EQUIPMENT:
SKIN:
NOT NECESSARY UNDER NORMAL PRODUCT USE CONDITIONS. WEAR NEOPRENE OR NATURAL
RUBBER GLOVES WHEN HANDLING A DAMAGED BATTERY.
PERSONAL PROTECTIVE EQUIPMENT:
RESPIRATORY: NOT NECESSARY UNDER NORMAL PRODUCT USE CONDITIONS.
PERSONAL PROTECTIVE EQUIPMENT:
GENERAL: EYEWASH FOUNTAINS AND EMERGENCY SHOWERS ARE REQUIRED.
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: VARIOUS SHAPED BATTER
ODOR: NONE
PHYSICAL STATE: SOLID
PH: NA
VAPOR PRESSURE: NA
VAPOR DENSITY: NA
BOILING POINT: NA
MELTING POINT: NA
SOLUBILITY (H2O): INSOLUBLE
SPECIFIC GRAVITY: NA
EVAPORATION RATE: NA
VOC: NA
OCTANOL/H2O COEFF.: NA
FLASH POINT: NA
FLASH POINT METHOD: NA
UPPER FLAMMABILITY LIMIT (UFL): NA
LOWER FLAMMABILITY LIMIT (LFL): NA
BURNING RATE: NA
AUTO IGNITION: NA
| SECTION 10 - STABILITY AND REACTIVITY | |
CHEMICAL STABILITY: THIS IS A STABLE MATERIAL.
CHEMICAL STABILITY:
CONDITIONS TO AVOID: AVOID EXPOSURE TO ELEVATED TEMPERATURES AND FIRE.
INCOMPATIBILITY: NOT AVAILABLE.
HAZARDOUS DECOMPOSITION:
MAY RELEASE TOXIC FUMES IF BURNED OR EXPOSED TO FIRE.
POSSIBILITY OF HAZARDOUS REACTIONS: NOT AVAILABLE.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
ACUTE DOSE EFFECTS:
A:
GENERAL PRODUCT INFORMATION:
IF PRODUCT IS RUPTURED, MATERIAL MAY CAUSE IRRITATION TO THE SKIN, EYES
AND RESPIRATORY TRACT.
B:
COMPONENT ANALYSIS - LD50/LC50:
NO LD50/LC50'S ARE AVAILABLE FOR THIS PRODUCT'S COMPONENTS.
CARCINOGENICITY:
A:
GENERAL PRODUCT INFORMATION: NO INFORMATION AVAILABLE FOR THE PRODUCT.
B:
COMPONENT CARCINOGENICITY:
NONE OF THIS PRODUCT'S COMPONENTS ARE LISTED BY ACGIH, IARC, OSHA, NIOSH,
OR NTP.
| SECTION 12 - ECOLOGICAL INFORMATION | |
ECOTOXICITY:
A:
GENERAL PRODUCT INFORMATION: NO INFORMATION AVAILABLE FOR THE PRODUCT.
B:
COMPONENT ANALYSIS - ECOTOXICITY - AQUATIC TOXICITY:
NO ECOTOXICITY DATA ARE AVAILABLE FOR THIS PRODUCT'S COMPONENTS.
| SECTION 13 - DISPOSAL CONSIDERATIONS | |
US EPA WASTE NUMBER & DESCRIPTIONS:
COMPONENT WASTE NUMBERS:
NO EPA WASTE NUMBERS ARE APPLICABLE FOR THIS PRODUCT'S COMPONENTS.
DISPOSAL INSTRUCTIONS:
RECYCLE BATTERY. DO NOT DISPOSE OF IN WATER BODIES OR SEWER SYSTEM.
ALL WASTES MUST BE HANDLED IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.
SEE SECTION 7 FOR HANDLING PROCEDURES. SEE SECTION 8 FOR PERSONAL
PROTECTIVE EQUIPMENT RECOMMENDATIONS.
| SECTION 14 - TRANSPORT INFORMATION | |
LITHIUM-ION BATTERIES COMPLY WITH ALL APPLICABLE SHIPPING REGULATIONS AS
PRESCRIBED BY INDUSTRY AND LEGAL STANDARDS WHICH INCLUDE UN RECOMMENDATIONS
ON THE TRANSPORT OF DANGEROUS GOODS; THE 62ND EDITION OF THE IATA DANGEROUS
GOODS REGULATIONS AND US DOT REQUIREMENTS. CELLS AND BATTERIES HAVE BEEN
TESTED TO SECTION 38.3 OF THE UN RECOMMENDATIONS ON THE TRANSPORT OF
DANGEROUS GOODS MANUAL OF TESTS AND CRITERIA. ALL OF THE BATTERIES LISTED
IN THIS SAFETY DATA SHEET ARE GREATER THAN 100 WHRS; THEREFORE, MOST MODES
OF TRANSPORTATION REQUIRE THE BATTERIES TO BE SHIPPED AS FULLY REGULATED
CLASS 9 HAZARDOUS MATERIAL. IN THE UNITED STATES, 49 CFR 173.185(C)(1)(IV)
OF THE HAZARDOUS MATERIALS REGULATIONS PROVIDES AN EXCEPTION FROM FULLY
REGULATED CLASS 9 SHIPPING WHEN SHIPPING BATTERIES UP TO 300 WHRS BY MOTOR
VEHICLE OR RAIL CAR. ALL AIR SHIPMENTS OF LITHIUM ION BATTERIES WITHOUT
EQUIPMENT REQUIRE THE STATE OF CHARGE OF THE BATTERY TO BE NO GREATER THAN
30% OF THE RATED DESIGN CAPACITY AND ARE BANNED FROM SHIPMENT ON PASSENGER
AIRCRAFT (CARGO AIRCRAFT ONLY).
BATTERIES ALONE:
UN3480, LITHIUM ION BATTERIES
AIR SHIPMENTS (IATA) - PACKING INSTRUCTION 965 (SECTION IA)
SEA SHIPMENTS (IMDG CODE, 2018 EDITION, INCLUDING AMENDMENT 39-18) -
PACKING INSTRUCTION P903
EUROPE ROAD TRANSPORTATION (ADR) - PACKING INSTRUCTION P903
US ROAD TRANSPORTATION (DOT) - 49 CFR 173.185(C)(1)(IV)
BATTERIES WITH OR IN EQUIPMENT:
UN3481, LITHIUM ION BATTERIES PACKED WITH EQUIPMENT OR LITHIUM ION
BATTERIES CONTAINED IN EQUIPMENT.
AIR SHIPMENTS (IATA) - PACKING INSTRUCTION 966 OR 967, SECTION I
SEA SHIPMENTS (IMDG CODE, 2018 EDITION, INCLUDING AMENDMENT 39-18) -
PACKING INSTRUCTION P903
EUROPE ROAD TRANSPORTATION (ADR) - PACKING INSTRUCTION P903
US ROAD TRANSPORTATION (DOT) - 49 CFR 173.185(C)(1)(IV)
| SECTION 15 - REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
A:
GENERAL PRODUCT INFORMATION:
ALL COMPONENTS ARE ON THE U.S. EPA TSCA INVENTORY LIST.
B:
COMPONENT ANALYSIS:
NONE OF THESE PRODUCT'S COMPONENTS ARE LISTED UNDER SARA SECTION 302
(40 CFR 355 APPENDIX A), SARA SECTION 313 (40 CFR 372.65), OR CERCLA
(40 CFR 302.4).
STATE REGULATIONS:
A:
GENERAL PRODUCT INFORMATION: NO ADDITIONAL INFORMATION AVAILABLE.
B:
COMPONENT ANALYSIS - STATE:
NONE OF THIS PRODUCT'S COMPONENTS ARE LISTED ON THE STATE LISTS FROM CA,
MA, MN, NJ, PA, OR RI.
CANADIAN WHMIS INFORMATION:
A:
GENERAL PRODUCT INFORMATION:
THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH THE HAZARD CRITERIA
OF THE CONTROLLED PRODUCTS REGULATIONS.
B:
COMPONENT ANALYSIS - WHMIS IDL: NO COMPONENTS ARE LISTED IN THE WHMIS IDL.
ADDITIONAL REGULATORY INFORMATION: NONE
| SECTION 16 - OTHER INFORMATION | |
OTHER INFORMATION:
THE INFORMATION HEREIN IS PRESENTED IN GOOD FAITH AND BELIEVED TO BE
ACCURATE AS OF THE EFFECTIVE DATE GIVEN. HOWEVER, NO WARRANTY, EXPRESSED
OR IMPLIED, IS GIVEN. IT IS THE BUYER'S RESPONSIBILITY TO ENSURE THAT ITS
ACTIVITIES COMPLY WITH FEDERAL, STATE OR PROVINCIAL, AND LOCAL LAWS.
KEY/LEGEND:
EPA: ENVIRONMENTAL PROTECTION AGENCY
TSCA: TOXIC SUBSTANCE CONTROL ACT
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
NIOSH: NATIONAL INSTITUTE FOR OCCUPATIONAL SAFETY AND HEALTH
NTP: NATIONAL TOXICOLOGY PROGRAM
OSHA: OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION.
NJTSR: NEW JERSEY TRADE SECRET REGISTRY
WHMIS: WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM (CANADA)
REVISION: 4.05
ISSUED: 6/2/2021